2004 BMW M33.2L Petrol

The 2004 BMW M3 presents a clean and stable maintenance trend, with the most recent MOT on 1 August 2025 at 102,401 miles passing with zero defects. Every recorded test in the available history, stretching back to October 2020, has passed without a single advisory or failure. This is an unusually spotless record for a 22-year-old high-performance vehicle and suggests a conscientious approach to upkeep, with no recurring mechanical or structural faults flagged by any tester over a five-year window. The mileage pattern tells a story of very light use. The car covered just 1,471 miles between the June 2024 test at 100,930 miles and the August 2025 test at 102,401 miles, following a similarly modest 1,347 miles between May 2023 and June 2024. The longer gap between March 2022 at 93,579 miles and October 2020 at 92,280 miles shows only 1,299 miles in roughly 18 months, indicating the car may have sat unused for extended periods. At roughly 4,655 miles per year over its life, this is well below the UK average, which reduces consumable wear but raises its own concerns around long-term fluid degradation, seal condition, and brake corrosion from standing. Despite the clean MOT record, a buyer should still inspect components that MOT tests do not fully stress. The E46 M3 is known for rear subframe mounting point cracking, particularly around the rear axle carrier, so a thorough underside inspection with the car on a lift is essential. Suspension bushes, particularly the rear trailing arm bushes and front control arm bushes, should be checked for perishing given the car's age, even if mileage is low. The S54 straight-six engine should be examined for VANOS seal degradation, oil leaks from the valve cover gasket and oil pan, and any signs of coolant system neglect, including the plastic expansion tank and thermostat housing, which are common failure points on this engine regardless of mileage. Brake calipers should be checked for seized pistons or sticking sliders, as low annual mileage can cause pads and discs to corrode rather than wear evenly. Tyre date codes deserve attention too; rubber degrades with age, and original or aged tyres with good tread depth can still be unsafe. The absence of any MOT advisories is encouraging, but it does not substitute for a pre-purchase inspection by a specialist familiar with the E46 M3's known structural and mechanical vulnerabilities.