2016 Hyundai i40 (VG)

Excessive steering free play and column knocking are standout failure areas in UK MOT data for the i40, failing at over 27 times the national fleet average. Internal degradation of the rubber star coupler inside the column-mounted electric power steering (C-MDPS) motor creates slack and a distinct clicking knock when rocking the wheel. In addition, internal wear in the steering rack gear teeth and tie-rod inner joints produces noticeable wandering at speed, vagueness around centre, and MOT failure for excessive steering movement.

Symptoms: Knocking or clicking sound felt through the steering column when oscillating the wheel, Noticeable dead zone or loose free play around the straight-ahead steering position...

Est. repair cost: £220–£950

Manual i40s fail early on the clutch side: owner-fault analyses report clutch trouble well before normal wear, with a supplier change around 2014 blamed for a run of cars needing replacement at 40,000-60,000 miles, and RAC's own owners' survey records grinding when changing gears. PistonHeads owners describe exactly this car needing a clutch and flywheel job to fix hard-to-select ratios. The tell is a cold gearbox that fights reverse and first and a shudder through the pedal pulling away; on a £2,000 car a £500-£1,200 clutch and dual-mass flywheel bill is a genuine write-off risk.

Symptoms: Grinding or resistance selecting first and reverse when cold, Clutch judder pulling away from junctions...

Est. repair cost: £500-£1,200 (clutch and dual-mass flywheel)

Fault File's owner and MOT analysis of the i40 calls out DPF regeneration failure on the short-run CRDi cars: a check-engine light that clears for a few dozen miles then returns, limp-mode power loss and smoke on start-up, recurring even after fuel-pump or injector work because the small filter simply never reaches regeneration temperature on school-run duty cycles. Get Car Wise's guide puts fixing it anywhere from a cheap forced regeneration to a four-figure filter replacement, and removal is illegal for road use. UK buyers should assume any i40 diesel that has lived in town is carrying this bill unspent.

Symptoms: Engine or DPF warning that returns after resetting, Limp mode after long urban runs...

Est. repair cost: £500-£2,000 (forced regen and clean through to DPF replacement)

The dry dual-clutch transmission (7-speed DCT) introduced with the 2015 facelift frequently develops severe shudder and hesitation during urban use. Repeated low-speed crawling in heavy UK traffic causes the dry friction plates to overheat and glaze, resulting in bunny-hopping when pulling away from rest and delayed gear engagement when shifting between Drive and Reverse. While dealer software recalibration and actuator relearn can temporarily alleviate mild cases, glazed or worn clutch packs require physical replacement and actuator realignment.

Symptoms: Violent juddering or shudder through the car when pulling away from standstill, Noticeable hesitation and delayed engagement when selecting Drive or Reverse...

Est. repair cost: £450–£1,500

A widespread cosmetic defect on the i40 involves rust blisters developing along the leading edge of the roof panel where it joins the windscreen. Thin factory paint application and trapped moisture along the windscreen glass seal allow corrosion to seed underneath the paint layer, presenting as a series of pimples or bubbling blisters. Dealerships frequently disputed warranty claims by attributing the blistering to stone chips, but owners across the UK report identical corrosion lines that eventually require windscreen extraction, metal grinding, and a full roof respray.

Symptoms: Small bubbling paint blisters along the leading roof edge above the windscreen, Orange rust bleeding onto the rubber seal at the top corners of the windscreen...

Est. repair cost: £350–£850