IsItAGoodCar
Reliability Guide

Common Problems with the
2016 Audi A6 Mk4 (C7)

We've identified 6 known issues that can affect the 2016 Audi A6 Mk4 (C7). 3 of these are serious faults that could be expensive to repair.

6
Known Issues
3
Serious
3
Moderate
0
Minor

All Known Issues

3.0 TDI Timing Chain Rattle

SeriousEngine

The V6 TDI timing chains sit at the rear of the engine and the hydraulic tensioners can weaken, causing cold-start rattle and potential chain jump if ignored.

Est. Repair Cost: £1,500–£3,000
Warning Signs:

Loud metallic rattle on cold start, Timing fault codes, Rough running

What to Inspect:
  • Insist on a stone-cold start
  • Ask for oil change history (avoid long-life 18k intervals)
  • Scan for timing correlation faults
Verified by IsItAGoodCar Research TeamUpdated

Adaptive Air Suspension Leak

SeriousSuspension & Chassis

Cars with optional adaptive air suspension develop leaks in the air struts, causing the car to sag and the compressor to overwork and fail.

Est. Repair Cost: £700–£2,000
Warning Signs:

Car sitting low after parking, Compressor running for too long, Level-control warning

What to Inspect:
  • Check ride height before startup
  • Listen for compressor noise
  • Inspect struts for leaks
Verified by IsItAGoodCar Research TeamUpdated

DL501 S tronic Mechatronic / Clutch Faults

SeriousGearbox & Transmission

The DL501 can develop control and clutch faults that cause harsh engagement or loss of gears. Confirm the transmission code rather than applying this warning to Multitronic or Tiptronic cars.

Warning Signs:

Jerky pull-away, Missing reverse or gearbox warning

What to Inspect:
  • Test low-speed shifts both cold and warm
  • Ask for fluid-service history and specialist fault diagnosis
Verified by IsItAGoodCar Research TeamUpdated

Coolant Leak in Engine "V"

ModerateCooling System

The coolant shut-off valve fails, filling the engine "V" between the cylinder banks with coolant, causing a gradual loss that can lead to overheating if not topped up.

Est. Repair Cost: £400–£900
Warning Signs:

Loss of coolant, Sweet smell from engine bay

What to Inspect:
  • Use a torch to look deep into the "V" between cylinder banks
  • Check the coolant expansion tank level when cold and watch for a steady drop
Verified by IsItAGoodCar Research TeamUpdated

DPF Clogging and Regeneration Issues

ModerateExhaust & Emissions

Town-driven 3.0 TDI models block their DPFs, causing warning lights, limp mode and expensive DPF cleaning or replacement.

Est. Repair Cost: £250–£1,200
Warning Signs:

DPF warning light, Limp mode, Poor throttle response

What to Inspect:
  • Ask about driving patterns
  • Scan for DPF soot load
  • Check MOT history for emissions advisories
Verified by IsItAGoodCar Research TeamUpdated

Electrical Module and Sensor Faults

ModerateElectrics & Electronics

Various electrical issues including MMI glitches, parking sensor failures, steering lock module faults and battery drain from comfort module issues.

Est. Repair Cost: £0–£600
Warning Signs:

MMI freezes, Parking sensor failures, Battery drain

What to Inspect:
  • Test all electrical systems
  • Scan for fault codes
  • Check for battery drain on overnight stand
Verified by IsItAGoodCar Research TeamUpdated

Buying Tips for 2016 Audi A6 Mk4 (C7)

  • Check for coolant leaks in the "V" of 3.0 TDI engines
  • S tronic (DSG) models need fluid changes every 38k miles
  • Listen for humming from the front wheels (wheel bearings)
Check a 2016 Audi A6 Mk4 (C7) by Registration