IsItAGoodCar
Reliability Guide

Common Problems with the
2007 BMW 5 Series (E60/E61)

March 2007 brought the LCI facelift with revised lights, a new cabin and the N47 520d. Shift-by-wire automatic, LED tail lights and brake energy regeneration modernised the car, and CIC iDrive arrived in 2009.

What changed for 2007

  • •N47 177PS 520d replaces the M47; 530d rises to 235PS
  • •N53 direct-injection engines for 523i, 525i and 530i
  • •Revised headlights, tail lights and front bumper; upgraded interior
  • •Shift-by-wire gear lever, steering-wheel paddles and brake energy regeneration

Common MOT watch-outs

  • !N47 timing chain rattle from the rear of the engine
  • !Rear air suspension leaks on the E61 Touring
  • !Water in the boot well damaging the battery and modules
5
Known Issues
4
Serious
1
Moderate
0
Minor

All Known Issues

Swirl Flap Ingestion (M47 & M57 Engines)

SeriousEngine

The plastic or metal swirl flaps in the intake manifold can break and be sucked into the engine, causing catastrophic piston and valve damage.

Est. Repair Cost: £150 (Blanking) / £3,000 (Rebuild)
Warning Signs:

Sudden loss of power, Rough running or metallic banging noise, Engine refusing to start after a loud pop

What to Inspect:
  • Ask for proof that swirl flaps have been "blanked" or removed
  • Look for evidence of intake manifold replacement
  • Listen for any unusual rattling from the manifold area
Verified by IsItAGoodCar Research TeamUpdated

Active Steering Faults

SeriousSteering

The active steering rack uses a planetary gear and electric motor to vary the steering ratio. Sensor failures or wiring issues can lead to an off-center steering wheel.

Est. Repair Cost: £400–£1,500
Warning Signs:

Steering wheel permanently off-center while driving straight, "Active Steering Inactive" warning on dash, Inconsistent steering weight

What to Inspect:
  • Check the steering wheel position carefully on a straight road
  • Verify all warning lights are out
  • Listen for any grinding or clicking from the rack when stationary
Verified by IsItAGoodCar Research TeamUpdated

Micro Power Module (MPM) Flooding

SeriousElectrics & Electronics

The MPM and other modules are located at the lowest point of the boot. Blocked sunroof drains or boot seal leaks can flood the area and fry the electronics.

Est. Repair Cost: £200–£600
Warning Signs:

Complete loss of iDrive and audio, Battery drain issues, Random electrical gremlins

What to Inspect:
  • Lift the spare wheel and check for any signs of water, dampness, or corrosion
  • Inspect the module connectors for green oxidation
  • Check for the "BMW 5 Series water ingress" recall fix
Verified by IsItAGoodCar Research TeamUpdated

Panoramic Roof Leaks (E61 Touring)

SeriousBodywork & Rust

The drains for the large panoramic roof block with debris, causing water to overflow into the rear D-pillars and the boot floor electronics.

Est. Repair Cost: £300–£1,000
Warning Signs:

Wet headlining or rear carpets, Musty smell, Electrical failures in the rear of the car

What to Inspect:
  • Inspect the rear D-pillars for water staining
  • Check for water in the battery and module compartments
  • Ask if the drain "nipples" have been removed or modified
Verified by IsItAGoodCar Research TeamUpdated

iDrive (CCC) System Failure

ModerateElectrics & Electronics

The early "CCC" iDrive units are prone to internal hardware failure, often caused by capacitor or solder issues due to heat.

Est. Repair Cost: £300–£800
Warning Signs:

Screen stuck on the BMW logo, Constant reboots or blank screen, Slow response and audio cutting out

What to Inspect:
  • Operate the iDrive for at least 15 minutes during the test drive
  • Check if the navigation DVD reads correctly
  • Listen for the internal fan running loudly
Verified by IsItAGoodCar Research TeamUpdated

Buying Tips for 2007 BMW 5 Series (E60/E61)

  • Listen for a cold-start chain rattle and check for N47 chain receipts
  • On a Touring, leave it parked overnight and check the rear ride height
  • Lift the boot floor and inspect the battery well for damp
20062008
Check a 2007 BMW 5 Series (E60/E61) by Registration