IsItAGoodCar
Reliability Guide

Common Problems with the
2005 BMW Z4 (E85/E86)

The 2.0i arrived in May 2005, bringing the N46 four-cylinder and a lower price point. It is the most economical E85 but also the least desirable to enthusiasts, and it was sold only in Europe.

What changed for 2005

  • •2.0i N46 150PS four-cylinder added for European markets including the UK
  • •Six-speed manual gearbox standard on the new four-cylinder
  • •Lower CO2 and insurance group than the six-cylinder cars

Common MOT watch-outs

  • !Valve cover gasket and oil filter housing leaks
  • !Timing chain wear on neglected N46 engines
  • !Small brake discs corroding through lack of use
4
Known Issues
1
Serious
3
Moderate
0
Minor

All Known Issues

Roof Motor Water Damage

SeriousBodywork & Rust

The electric roof motor is located in a drainage cavity that blocks with leaves and debris. The motor eventually sits in a pool of water and rusts solid.

Est. Repair Cost: £400–£800
Warning Signs:

Roof refusing to move when the button is pressed, Motor making a faint "struggling" sound but no movement, Manual release must be used to move the roof

What to Inspect:
  • Ask if the motor has been "relocated to the boot", which is the permanent fix
  • Check the drainage holes in the roof storage compartment for blockages
  • Test the roof operation several times in quick succession
Verified by IsItAGoodCar Research Team

Sticky Steering (EPS Column)

ModerateSteering

The grease in the electric power steering column can dry out or the components expand with heat, causing the steering to feel "sticky" or notchy on center.

Est. Repair Cost: £500–£1,000
Warning Signs:

Steering feels "stuck" when driving straight at motorway speeds, Small steering corrections feel notchy or require more force than normal, Problem gets worse as the cabin/engine bay warms up

What to Inspect:
  • Take the car for a long test drive to get it fully warm
  • Check for steering wheel corrections that feel inconsistent or lack "flow"
  • Ask if the steering column has been adjusted or replaced
Verified by IsItAGoodCar Research Team

Rear Coil Springs Snapping

ModerateSuspension & Chassis

The brittle rear springs often snap at the very bottom coil due to the car's weight distribution and UK potholes. It can be hard to spot without inspection.

Est. Repair Cost: £150–£300
Warning Signs:

Metallic pinging noise from the rear, One corner of the car sitting slightly lower than the other, Knocking over speed bumps

What to Inspect:
  • Shine a torch into the rear wheel arch and inspect the bottom coil of the spring
  • Check both sides, as they are usually replaced in pairs
Verified by IsItAGoodCar Research Team

DISA Valve Rattle (M54 Engine)

ModerateEngine

The flap inside the intake manifold (DISA valve) can work loose. If the metal pin falls out, it can be ingested by the engine, causing total failure.

Est. Repair Cost: £100–£250
Warning Signs:

Tapping or rattling noise from the intake side of the engine, Loss of low-end torque, Rough idling

What to Inspect:
  • Listen for a rattle from the black box on the side of the intake manifold
  • Unplug the DISA electrical connector while running to see if the rattle stops
  • Ask if an aluminium upgrade kit has been fitted
Verified by IsItAGoodCar Research Team

Buying Tips for 2005 BMW Z4 (E85/E86)

  • Check for oil weeping down the front of the engine and bellhousing
  • Listen for a rattle from the front timing cover on cold start
  • Do not pay six-cylinder money for a 2.0i, however tidy it looks
20042006
Check a 2005 BMW Z4 (E85/E86) by Registration