2010 Vauxhall Zafira 1.6L Petrol · DY10 PRZ

The vehicle currently holds a roadworthy status following a clean pass in September 2025 at 92,735 miles. This represents a significant improvement in the maintenance trend compared to the previous year, where multiple defects were identified. While the most recent test shows no recorded faults, the history reveals a pattern of reactive maintenance where components are addressed only after failing or receiving an advisory, rather than through a proactive replacement schedule. At 16 years old, the recorded 92,735 miles reflect a low annual usage rate of approximately 5,800 miles. The data shows a relatively consistent but infrequent interval between 2022 and 2025, with the vehicle covering roughly 11,500 miles over that three-year period. This low mileage suggests the mechanical wear on the drivetrain and engine is lower than average, but it often leads to the degradation of rubber-based components and increased corrosion, which is consistent with the rust-related issues found in the records. A buyer must focus specifically on the structural integrity and suspension components during a physical inspection. The August 2024 test flagged a corroded front sub-frame and a corroded offside rear coil spring; although these were not yet weakened at the time, corrosion on Vauxhall chassis components tends to accelerate once it begins. You should also inspect the exhaust system for further leaks, as the record shows a history of back box issues and defective clamps dating back to 2022 that required rectification after a failed test in 2023. The braking system also requires close attention due to recurring issues with pitted brake discs and thin pads noted between 2022 and 2023. The previous corrosion on the offside front brake hose ferrule in 2022 should be checked for any signs of leaking or perished rubber. Given that the 2024 test also flagged front tyres worn to the legal limit, ensure the current tyres have been replaced and do not show uneven wear, which would indicate underlying alignment or suspension geometry problems.