2001 Vauxhall Zafira 1.8L Petrol · XIA 328

The Zafira A's Z16XE and Z18XE petrol engines are interference engines driven by a cambelt that also runs the water pump, so a belt that snaps or skips teeth bends the valves and destroys the bottom end. GetCarWise's fault data puts the change interval at roughly 80,000 miles or five years, prices a belt-and-pump job at £350-£450 and values engine damage at £3,000-£5,000 - far more than the car is worth. BreakerLink's Zafira guide gives the same warning, that the belt needs regular replacement or the resulting damage is extensive and expensive. Most cars on the market are now past either limit and a service stamp is not proof the job was done.

Zafira A owners report the rear doors and tailgate locking circuit dropping out because the flexible loom between body and door cracks internally, a fault both BreakerLink and BreakerYard list for the 1999-2005 car. BreakerLink notes the Zafira is known to suffer an issue with the central locking in the back doors due to the electrics, with locks sticking so a door is hard to open; BreakerYard adds that the boot locking switch in the driver's door fails, so the tailgate refuses to release. Rear doors on a family MPV get slammed harder than any other part of the car, which is why the loom goes first.

Zafira A models manufactured between 1999 and 2005 were produced with defective front brake calipers that allowed hydrogen gas to accumulate inside the hydraulic calipers, causing a spongy and unresponsive brake pedal even after routine bleeding. BreakerYard notes that between 1999 and 2005 Zafiras suffered from faulty calipers that let gas enter the hydraulic system, requiring replacement calipers on both sides and a full system pressure flush. BreakerLink confirms that buyers of 1999 to 2005 cars must check for spongy, unresponsive brakes caused by manufacturing faults in the calipers. If neglected, braking efficiency is compromised, leading to MOT failure and extended stopping distances.