2012 MINI Roadster (R59)

Same engine as the Coupe and the same story: the 184hp Cooper S and 218hp JCW N18 Prince turbo is chain-driven with Valvetronic, and PistonHeads records the chain wearing on turbocharged cars when oil levels drop or heat degrades it across long service intervals, quoting around £850 to replace at a specialist, while Lohen prices its N18 chain-tensioner death-rattle fix at £820 fitted. The Roadster's enthusiast owners drive the hard way round, so cold-start rattle warrants serious suspicion; a skipped chain on an N18 is terminal to the engine.

Symptoms: Rattle for the first seconds of a cold start, Engine light with cam timing correlation codes...

Est. repair cost: £750-£950 specialist chain and tensioner job

PistonHeads lists the recall affecting the Roadster as the same range-wide auxiliary water-pump campaign of March 2019: cars built February and March 2011, across MINI and several BMW models, could have a pump circuit board short that Auto Express notes could potentially lead to a fire; the remedy is a new auxiliary pump, done free in campaign. Early Roadster build periods overlapped those production months, and PistonHeads says affected pumps were sometimes diagnosed as faulty without symptoms - so verify by VIN rather than trusting a clean-looking engine bay.

Symptoms: None required - failures could occur without drivability symptoms, Burning smell or smoke from the engine bay in the worst case...

Est. repair cost: £0 under recall; roughly £250-£500 for the pump once out of campaign

Auto Express's used check-up is direct about the Roadster top: every UK car has an electric roof with a locking handle the driver must release, the hood is a noisier single-layer item versus the Convertible's multi-layer roof, and a wind deflector was optional. PistonHeads adds that the top deploys in 18 seconds at up to 20 mph and is single-layer only. In practice that means perished or fouled seals, wind roar around the frame, sticking or worn handle locks, and pump or motor tiredness on cars that never run the roof through its cycle. Nothing catastrophic, but the roof is the whole value of the car and it is expensive to put right.

Symptoms: Roof hesitating, stopping or making laboured pump noises mid-cycle, Wind roar or draughts around the rear side windows with the top up...

Est. repair cost: £300-£1,200 from seal and handle repairs through to pump or motor replacement