IsItAGoodCar

Common Problems with the
2005–2007 Chrysler 300C

We've identified 4 known issues that can affect the 2005–2007 Chrysler 300C. 2 of these are serious faults that could be expensive to repair.

4
Known Issues
2
Serious
2
Moderate
0
Minor

The 2005–2007 period has 3 more issues than the Chrysler 300C average across all year periods.

All Known Issues

Swirl Motor Failure (3.0 CRD)

SeriousEngine

Oil leaks from the turbocharger intake pipe can drip directly onto the swirl flap motor located in the "V" of the engine, causing it to short out and put the car into limp mode.

Most affected: 3.0 CRD Diesel

Estimated cost: £400–£700Affects: 2005–2010

Typical symptoms

  • •Limp mode (limited power)
  • •Electronic Throttle Control (ETC) light
  • •Engine management light

What to inspect before you buy

  • ✓Check for oil residue around the turbo inlet
  • ✓Ask if a "resistor mod" or swirl motor bypass has been fitted

Inlet Manifold Corrosion (2005–2007 Diesel)

SeriousEngine

On early 300C diesels, the inlet manifold can corrode internally and suck plastic fragments into the engine, causing potentially catastrophic damage. Cars built between 2005 and 2007 are most affected.

Most affected: 3.0 CRD Diesel

Estimated cost: £400–£1,200Affects: 2005–2007Often appears around: 40,000–80,000 miles

Typical symptoms

  • •Loss of power
  • •Engine management light
  • •Metallic rattling from engine
  • •Engine damage if fragments ingested

What to inspect before you buy

  • ✓Check if the original inlet manifold has been replaced
  • ✓Ask about any engine damage history
  • ✓Listen for unusual engine noises

Suspension Bush & Ball Joint Wear

ModerateSuspension & Chassis

The 300C is a very heavy car, and its suspension components (derived from the Mercedes W211) take a beating on UK roads. Ball joints and control arm bushes often last less than 40,000 miles.

Most affected: All models

Estimated cost: £300–£800Affects: 2005–2015

Typical symptoms

  • •Knocking over speed bumps
  • •Vague steering
  • •Uneven tyre wear

What to inspect before you buy

  • ✓Service history for suspension work
  • ✓Listen for knocks during test drive
  • ✓Inspect front tyres for inner edge wear

Alternator Failure

ModerateElectrics & Electronics

The alternator is prone to premature failure, often caused by diesel fuel dripping onto it from cracking rubber fuel hoses. The earth cable can also corrode, leaving the car unable to start.

Most affected: 3.0 CRD Diesel

Estimated cost: £300–£700Affects: 2005–2015Often appears around: 50,000–100,000 miles

Typical symptoms

  • •Battery warning light
  • •Car failing to start
  • •Dimming lights
  • •Electrical glitches

What to inspect before you buy

  • ✓Check the alternator output voltage
  • ✓Inspect fuel hoses near the alternator for leaks
  • ✓Check the earth cable for corrosion

Buying Tips for the 2005 Chrysler 300C

  • ✓Listen for "knocking" from the front suspension over bumps; it usually means worn control arms or ARB bushes.
  • ✓On diesel models, check for the "red lightning bolt" warning light, which can indicate swirl motor or electronic throttle issues.
  • ✓Verify that the alternator is charging correctly, as failures are common and can leave you stranded.
  • ✓The facelift models (late 2008 onwards) have a much-improved interior and slightly better electrical reliability.
  • ✓Touring (Estate) versions are highly practical but check for sagging rear self-levelling suspension.
2008–2010 Chrysler 300C

Browse 2005–2007 Chrysler 300C in our Directory

View MOT history, registration data, and reliability scores for 2005–2007 Chrysler 300C vehicles.

View 2005–2007 Directory

Other Chrysler 300C Year Periods

2005–20072008–20102011–2015

Looking at a specific 2005 Chrysler 300C?

Enter the registration number to check its full MOT history, outstanding finance, write-off status, and more.

Free Vehicle Check