IsItAGoodCar

Common Problems with the
2013–2016 Ford Tourneo Connect (C515)

We've identified 4 known issues that can affect the 2013–2016 Ford Tourneo Connect (C515). 1 of these are serious faults that could be expensive to repair.

4
Known Issues
1
Serious
3
Moderate
0
Minor

The 2013–2016 period has 3 more issues than the Ford Tourneo Connect (C515) average across all year periods.

All Known Issues

PowerShift Gearbox Judder (Automatic Models)

SeriousGearbox & Transmission

The dry-clutch 6DCT250 PowerShift automatic suffers the same judder, hesitation and mechatronic failure issues as other Ford models. Urban stop-start use accelerates wear.

Most affected: 1.6 Petrol Powershift

Estimated cost: £800-£2,500Affects: 2013–2020Often appears around: 30,000-60,000 miles

Typical symptoms

  • •Judder when pulling away
  • •Hesitation on gear changes
  • •Transmission malfunction warning

What to inspect before you buy

  • ✓Drive in slow traffic from cold and warm
  • ✓Check for smooth reverse engagement
  • ✓Ask for gearbox fluid change history

DPF and Injector Issues (1.6 TDCi)

ModerateEngine

The 1.6-litre diesel is prone to injector seal failure and DPF clogging on short urban journeys. Leaking injector seals cause the Black Death, a build-up of carbon tar around the injectors.

Most affected: 1.6 TDCi

Estimated cost: £300-£1,000Affects: 2013–2016Often appears around: 60,000+ miles

Typical symptoms

  • •Misfire and rough idle
  • •Limp mode
  • •Frequent DPF regeneration messages
  • •Chuffing sound from engine

What to inspect before you buy

  • ✓Check for chuffing sound at idle
  • ✓Inspect injector bases for carbon build-up
  • ✓Scan for DPF soot-load percentage

Sliding Door Mechanism and Latch Faults

ModerateBodywork & Rust

The sliding rear doors can jam, fail to lock properly, or trigger dashboard warnings. Worn rollers, faulty latches and damaged wiring in the door channels are common, especially on family-used examples.

Most affected: All models

Estimated cost: £100-£400Affects: 2013–2024

Typical symptoms

  • •Door jamming or making scraping noises
  • •Door will not lock properly
  • •Dashboard door ajar warning

What to inspect before you buy

  • ✓Open and close both sliding doors repeatedly
  • ✓Check that all doors lock and unlock from the fob
  • ✓Inspect the door rails and rollers for wear

Electrical Gremlins and Battery Drain

ModerateElectrics & Electronics

General electrical issues include battery drain, infotainment glitches, heated windscreen segment failures and door-module faults. The car can go flat if left unused for more than a few days.

Most affected: All models

Estimated cost: £80-£400Affects: 2013–2024

Typical symptoms

  • •Flat battery after standing
  • •Infotainment freezing
  • •Heated windscreen dead zones
  • •Phantom warning lights

What to inspect before you buy

  • ✓Check battery age and state of charge
  • ✓Test all electrical functions
  • ✓Check the heated windscreen for dead zones

Buying Tips for the 2013 Ford Tourneo Connect (C515)

  • ✓Avoid the 1.0 EcoBoost unless it has perfect service history as the wet-belt risk is the same as other Ford models.
  • ✓On 1.6 TDCi models, check for injector leaks and DPF health, especially if used for short urban trips.
  • ✓Test both sliding doors and their locking mechanisms; the rollers and latches wear out with heavy family use.
2017–2020 Ford Tourneo Connect (C515)

Browse 2013–2016 Ford Tourneo Connect (C515) in our Directory

View MOT history, registration data, and reliability scores for 2013–2016 Ford Tourneo Connect (C515) vehicles.

View 2013–2016 Directory

Other Ford Tourneo Connect (C515) Year Periods

2013–20162017–20202021–2024

Looking at a specific 2013 Ford Tourneo Connect (C515)?

Enter the registration number to check its full MOT history, outstanding finance, write-off status, and more.

Free Vehicle Check