Common Problems with the
2007–2008 Hyundai i30 (FD)

We've identified 2 known issues that can affect the 2007–2008 Hyundai i30 (FD). None are considered critical, but they're worth knowing about before you buy.

Known Issues

Serious

Moderate

Minor

The 2007–2008 period has 1 more issue than the Hyundai i30 (FD) average across all year periods.

All Known Issues

EGR, DPF and injector issues on 1.6 CRDi

ModerateExhaust & Emissions

The diesel engine can cover serious mileage, but older cars used mainly for short trips develop EGR, DPF and injector issues that easily outweigh the value of a cheap example.

Most affected: 1.6 CRDi

Estimated cost: £180–£1,000Affects: 2007–2011Often appears around: 60,000–140,000 miles

Typical symptoms

•Hesitation under load
•Limp mode
•Uneven idle
•DPF warning light or excess smoke

What to inspect before you buy

✓Cold-start smoke and idle
✓History of EGR or DPF cleaning
✓Evidence of regular motorway use
✓Injector-seal condition

Front spring, top-mount and bush wear

ModerateSuspension & Chassis

Broken spring ends, tired top mounts and worn lower-arm bushes are common on UK cars and explain a lot of FD clonks or vague tracking.

Most affected: All FD hatchback and estate models

Estimated cost: £180–£420Affects: 2007–2011Often appears around: 50,000–120,000 miles

Typical symptoms

•Clonk over potholes
•Car sitting slightly low
•Wandering steering on poor roads

What to inspect before you buy

✓Inspect lower spring coils for rust or fractures
✓Look for repeat advisories on bushes or dampers
✓Check front tyre wear consistency

Buying Tips for the 2007 Hyundai i30 (FD)

✓Condition matters more than trim because tired cheap FD cars quickly need springs, brakes and suspension arms to pass the next MOT
✓Petrol manuals are the easiest route into ownership; older diesels need proper motorway use and better maintenance than bargain adverts usually admit
✓Listen for front-end clonks and make sure the steering feels consistent rather than rubbery or loose
✓Check under the rear of the car for tired exhaust sections, corroded brake pipes and damp rear dampers

2009 Hyundai i30 (FD)