IsItAGoodCar

Common Problems with the
2005–2010 Saab 9-5 OG

We've identified 4 known issues that can affect the 2005–2010 Saab 9-5 OG. 2 of these are serious faults that could be expensive to repair.

4
Known Issues
2
Serious
1
Moderate
1
Minor

The 2005–2010 period has 1 more issue than the Saab 9-5 OG average across all year periods.

All Known Issues

Turbocharger Failure

SeriousEngine

All 9-5 engines use a turbocharger, and lack of maintenance or oil sludge can cause premature turbo bearing failure. A blown turbo can send oil into the intake or exhaust, causing smoke and potential engine damage.

Most affected: All turbo models

Estimated cost: £800–£2,000Affects: 1997–2010Often appears around: 80,000–120,000 miles

Typical symptoms

  • •White/blue smoke from exhaust
  • •Sudden loss of power
  • •Whistling or siren noise from engine bay
  • •Oil consumption increase

What to inspect before you buy

  • ✓Listen for turbo whistle on acceleration
  • ✓Check for oil in the intercooler pipework
  • ✓Look for signs of oil burning or smoke

Timing Chain Rattle (4-Cylinder Engines)

SeriousEngine

The timing chains on B205/B235 engines can stretch and rattle, especially on cold start. If the chain tensioner fails, the chain can skip teeth and cause valve-piston contact.

Most affected: 2.0t, 2.3t

Estimated cost: £500–£1,500Affects: 1997–2010Often appears around: 80,000–120,000 miles

Typical symptoms

  • •Rattling noise on cold start
  • •Engine management light
  • •Poor idle quality

What to inspect before you buy

  • ✓Listen for a metallic rattle for the first few seconds after cold start
  • ✓Check for oil feed to the chain tensioner
  • ✓Ask about oil change history

Rear Trailing Arm Bushes

ModerateSuspension & Chassis

Worn rear bushes lead to poor tracking and high tyre wear.

Most affected: All models

Estimated cost: £200–£400Affects: 1997–2010Often appears around: 60k-100k miles

Typical symptoms

  • •"Ghost steering" from the rear
  • •Knocking over speed bumps

What to inspect before you buy

  • ✓Check rear tyre inner edge wear

ACC Blend Door Failure

MinorInterior & Trim

The plastic arm or shaft for the heater blend door snaps, leaving one side of the car at the wrong temperature.

Most affected: All with Automatic Climate Control

Estimated cost: £100–£400Affects: 1997–2010Often appears around: 80k+ miles

Typical symptoms

  • •Fault code 08 or 11 on ACC display
  • •Inconsistent cabin temperature

What to inspect before you buy

  • ✓Run the ACC calibration (press Auto and Off together)
  • ✓Verify heat/cool on both sides

Buying Tips for the 2005 Saab 9-5 OG

  • ✓Prioritise cars with a documented sump drop and PCV update.
  • ✓Check the dual-zone climate control; if it only blows hot/cold on one side, a blend door arm has likely snapped.
  • ✓On estates, check the rear wheel arches for rust starting under the plastic trim.
  • ✓Automatic gearboxes (Aisin-Warner) are robust but need fluid changes.
1997–2004 Saab 9-5 OG

Browse 2005–2010 Saab 9-5 OG in our Directory

View MOT history, registration data, and reliability scores for 2005–2010 Saab 9-5 OG vehicles.

View 2005–2010 Directory

Other Saab 9-5 OG Year Periods

1997–20042005–2010

Looking at a specific 2005 Saab 9-5 OG?

Enter the registration number to check its full MOT history, outstanding finance, write-off status, and more.

Free Vehicle Check