2007 Vauxhall Vivaro 2.0L Diesel · MF57 AEU

The 2007 Vauxhall Vivaro shows a history of progressive mechanical and structural wear consistent with its high mileage. The most recent test in July 2024 at 180,863 miles saw the vehicle pass but flagged several significant concerns, including a corroded and greased offside rear brake pipe and structural corrosion on the offside front jack point. While the tester noted structural rigidity was not significantly reduced, the presence of rust on load points is an ongoing issue that requires close monitoring. The nearside front inner CV boot has remained severely deteriorated across multiple years, indicating a failure to address this drivetrain vulnerability. The vehicle has covered 180,863 miles over 19 years, averaging approximately 9,500 miles per year. This is typical for a commercial vehicle of this age, yet the record reveals a pattern of reactive maintenance regarding consumable items. In August 2023, the van failed at 170,666 miles due to failed stop lamps, thin brake pads, and tyres reaching the legal limit. Although these were rectified shortly after, the subsequent 2024 test showed new issues such as a perished offside rear tyre and defective wiper blades, suggesting that basic upkeep is only performed when an MOT failure is imminent. Suspension and braking components show signs of persistent fatigue. The sub-frame pins and bushes were flagged as worn in 2023, and while they did not cause excessive movement then, they indicate significant age on the front end assembly. The recurring oil leak noted in 2024, while described as not excessive, is a common trait for engines of this mileage. A prospective buyer should inspect deeply for further structural rot around the front chassis and ensure the CV boots are replaced to prevent catastrophic damage to the drive shaft joints.