1981 Citroen HY 1.9L Diesel · NUX 192W

The maintenance trend for this Citroen HY is deeply concerning, shifting from minor corrosion advisories to severe structural failures before the record abruptly halts. The most recent test, dated 1 October 2021 at 70,610 miles, passed, but only after the vehicle presumably underwent extensive welding repairs to rectify a catastrophic failure just weeks prior. The September 2021 failure at 70,609 miles revealed excessive corrosion compromising the structural integrity of the cab mountings, specifically the nearside front cab and chassis, nearside outrigger, nearside rear chassis, and both front flitches. The tester also flagged binding front brake calipers, imbalanced front brakes, and insufficient service brake efficiency. The current status is highly questionable, as no MOT exists for the last four and a half years, rendering the vehicle effectively unroadworthy and untaxed for road use since October 2024. The recorded mileage of 70,610 miles across 45 years equates to a mere 1,569 miles annually, indicating exceptionally light use or prolonged periods of dormancy. Between March 2018 and April 2019, the vehicle covered 3,763 miles, but the subsequent climb from 68,025 miles in April 2019 to 70,533 miles in July 2020 shows a slightly increased usage of 2,508 miles over fifteen months. The mileage then plateaued drastically, accumulating only 77 miles between July 2020 and September 2021. Such minimal recent motoring suggests the van may have been stored or barely driven, which often accelerates deterioration of rubber components and brake mechanisms due to standing. A prospective buyer must conduct a rigorous physical inspection of the chassis and structural mounts, as the 2021 corrosion failures indicate severe rust within 30cm of critical cab mounting points. While the subsequent October 2021 pass implies repairs were executed, the quality of welding on a 44-year-old chassis warrants professional scrutiny to ensure structural integrity persists. Brake system components demand equal attention; the tester noted binding calipers and imbalanced brakes in September 2021, and the 2020 record highlighted corroded brake pipes covered in grease, suggesting deferred maintenance. The slight play in the nearside front track rod end ball joint and the historical oil leak also point to aged suspension and engine seals. Given the extended gap without an MOT, a thorough assessment of all corrosion repairs, brake pipe condition, and steering linkages is essential before any road use.