2016 Peugeot Expert 2.0L Diesel · SF16 DFP

A pattern of intermittent mechanical failures concerning wear-and-tear components defines this vehicle's roadworthiness record, though it achieved a clean pass on 2026-05-22. Recent history shows a trend of failures occurring immediately prior to passing, most notably in May 2026 when the vehicle failed due to a severely deteriorated nearside front inner drive shaft constant velocity boot and insufficient parking brake efficiency. Earlier failures involving registration lamps, insecure door handles, and tyre cuts indicate a history of addressing defects only when flagged during the annual inspection. The recorded mileage of 124,897 miles is high for a ten-year-old vehicle, averaging approximately 12,490 miles per year. This level of usage typically results in accelerated wear on primary drivetrain components, suspension bushings, and braking systems. Such a high-mileage profile increases the likelihood of fatigue in structural mountings and the degradation of rubber seals and boots, as evidenced by the recent constant velocity boot failure. During a physical inspection and test drive, specific attention should be paid to the drivetrain and braking system. Listen for audible clicking or popping sounds from the front end during tight, low-speed manoeuvres, which would indicate that the recently replaced constant velocity boot or the joint itself remains a point of concern. The parking brake should be rigorously tested on an incline to ensure the efficiency issues flagged in May 2026 have been fully rectified and that the cable or shoes are not binding. Further scrutiny is required for the exhaust system and tyre condition. Given the previous advisory regarding a defective rear exhaust mounting, check for excessive movement or rattling of the exhaust pipework under acceleration. Additionally, the history of multiple tyre failures and advisories for worn edges suggests a need to inspect the current tyre tread depth and check for uneven wear patterns, which could point to underlying wheel alignment issues or worn suspension components.