2009 Volvo S40 1.8L Petrol · SL59 XOT

The Volvo S40 presents a stable and reassuring maintenance trend as of its most recent test on 2025-07-10 at 105,820 miles, where it passed with zero defects recorded. This clean bill of health follows a retest on the same day for a minor headlamp aim issue. The vehicle has transitioned from a period of recurring advisories to a fully compliant state, suggesting attentive remedial work by the current keeper. No active MOT advisories remain outstanding. The mileage accumulation is steady and entirely typical for a 2009 vehicle. Between 2023-06-28 at 101,594 miles and 2025-07-10 at 105,820 miles, the car covered 4,226 miles over roughly 24 months, averaging approximately 176 miles per month. This consistent, moderate use pattern is unlikely to have caused excessive drivetrain fatigue, though it confirms the vehicle was driven regularly rather than sitting idle for extended periods. Despite the recent clean test, the 2024-07-16 failure at 103,130 miles flagged a major rear exhaust leak alongside scored front brake discs. Buyers should physically inspect the full exhaust system for fresh corrosion or recent welding repairs. The front brake discs were flagged as worn and pitted in both 2023 and 2024, so checking disc thickness and condition is essential to verify whether the current set is original or recently replaced. The 2023-06-28 pass at 101,594 miles also identified a corroded radiator carrier bracket and a slightly distorted nearside front wheel. These findings point to potential under-body corrosion and suspension stress. A buyer should closely examine the front subframe and mounting points for rust, and check the nearside front tyre for uneven wear or bulging that could indicate lingering wheel or suspension damage.