2007 Ford Transit Connect 1.8L Diesel · YK57 TXC

The vehicle is currently roadworthy but the maintenance trend shows a concerning progression of structural and hydraulic degradation. While the vehicle passed the November 2025 test at 102,436 miles, the tester identified a corroded offside front brake pipe and general structural corrosion. This follows a recurring issue noted in October 2024, where three separate brake pipes were flagged for corrosion and being covered in grease. The persistence of these faults suggests that while reactive repairs are made, the underlying rate of oxidation is not being addressed. At 19 years old, the recorded mileage of 102,436 miles is notably low, averaging approximately 5,400 miles per year. The data shows consistent usage patterns, with roughly 5,000 miles driven between the October 2024 and 2025 tests. However, the low mileage may correlate with the accelerated corrosion seen in the record, as vehicles that sit for long periods often allow brake lines and suspension mounting points to deteriorate due to environmental exposure rather than mechanical wear and tear. A buyer must conduct a thorough physical inspection of the underside, specifically focusing on the areas flagged in October 2023 at 92,141 miles. That test revealed excessive corrosion on the nearside rear suspension component mounting which significantly reduced structural strength. Although the 2025 test noted structural rigidity is not yet significantly reduced, the presence of deep rust in these mounting points indicates a high risk of future failure. The brake pipe network should be inspected for weeping leaks or further thinning, as the grease mentioned in previous reports often indicates an attempt to hide active corrosion from the tester.