2006 Toyota Prius 1.5L Electric · FL06 ABF

The most recent official DVSA test took place on 2 June 2025 and resulted in a pass with no defects or advisories recorded, indicating the vehicle was deemed roadworthy at the time of examination. This latest result follows a consistent pattern of passes across the available history, with successful tests recorded in May 2024, May 2023, and May 2022. One prior failure is noted on 25 May 2023, though no defect details were logged against that entry; the immediate and successful re-test the following day suggests the issue was minor and rectified without difficulty. Overall, the trend presented is stable, with no accumulating advisories or repeat failure categories that would point to systemic neglect or worsening mechanical condition. The recorded mileage of 164,314 miles across a twenty-year service life equates to an annual average of approximately 8,216 miles, which is broadly typical for a vehicle of this age. The annual MOT cadence is consistent and the mileage progression between tests suggests regular if modest use rather than periods of extended standing or unusually high accumulation in short intervals. This usage pattern is generally favourable for long-term component longevity, as it tends to keep lubricants circulating, prevents seized calipers, and avoids the moisture accumulation associated with rarely driven vehicles. However, given the cumulative mileage and the known mechanical profile of the first-generation Toyota Prius hybrid system, drivetrain wear and battery degradation should still be considered realistic possibilities at this stage of life. Given the clean MOT history and absence of recorded advisories, a prospective purchaser should not rely solely on the DVSA record but should instead conduct a thorough physical inspection reflecting the vehicle's age and mileage. Attention should be paid to the condition of the tyres, as twenty-year-old rubber is highly susceptible to sidewall perishing and cracking from age even where tread depth remains adequate; any visible ozone cracking should be treated as an immediate replacement requirement regardless of remaining tread. The 12-volt auxiliary battery, which is a standard lead-acid unit separate from the high-voltage traction battery, is a known weak point on first-generation Prius models and typically requires replacement every four to six years; its condition should be verified and the date of last replacement established. The hybrid system itself, including inverter coolant condition, should be checked, and a diagnostic health check of the high-voltage battery pack is strongly recommended to confirm cell balance and state of health, as degradation here is common at high mileages. On a practical roadworthiness evaluation, the brake discs and calipers should be examined for corrosion and binding, particularly given that MOT brake tests can pass even where calipers are seizing slightly; on a test drive, any pulling to one side, a soft or inconsistent pedal, or juddering under braking would warrant further investigation. The suspension components, including front and rear anti-roll bar bushes, wishbone bushes, and coil springs, are subject to wear at this mileage, and any clonks, knocks, or uneven tyre wear on the nearside or offside edges may indicate deterioration. The exhaust system should be checked for corrosion around the heat shields and joints, and engine oil, transmission fluid, and coolant should be inspected for condition and age rather than just level, as calendar-based servicing remains essential even with modest annual mileage. A review of service book stamps or digital service records to confirm timely replacement of engine coolant, inverter coolant, brake fluid, and spark plugs will provide further reassurance, and a compression test on the petrol engine combined with a hybrid system health report would be prudent before purchase.