2020 Vauxhall Vivaro 3100 Dynamic S/S 2.0L Diesel · DN20 BFV

The most recent MOT test on 20 September 2025 at 57,275 miles resulted in a pass, but the tester flagged front brake discs worn, pitted or scored, though not seriously weakened. This advisory is a recurring theme. In the July 2023 test at 34,465 miles, the tester noted front brake discs worn on both sides. The front braking surfaces have therefore drawn attention across two consecutive tests, suggesting a persistent wear pattern rather than a one-off defect. The maintenance trend is broadly stable, with no dangerous failures recorded, yet the repeated disc wear indicates the front braking system is operating under consistent stress. The vehicle has not been tested since September 2025, so its current condition remains unverified beyond that date. The mileage progression tells a coherent story. From July 2023 to August 2024, the vehicle covered roughly 10,789 miles in thirteen months. From August 2024 to September 2025, it added 12,021 miles in thirteen months. Annual mileage sits around 9,546 miles over six years, which is typical for a working van. There are no suspicious gaps or sudden drops in recorded distance. The MOT history is relatively clean for a commercial vehicle of this age, with no outright failures and only minor advisories. Buyers should focus their physical inspection on the front braking system first. Pitted or scored discs suggest either aggressive driving, frequent heavy loads, or a caliper issue causing uneven pad contact. Have a technician measure disc thickness and run-out, and check the condition of the pads and slide pins. The drive shaft CV boot advisories from 2023 and 2024 were both for severely deteriorated outer boots on both sides. If these were replaced, inspect the joints for play or clicking on full lock. If not, budget for new boots and joints, as a split boot leads to grease loss and joint failure. Beyond the flagged items, examine the chassis and load floor for corrosion, particularly around suspension mounting points and wheel arches. Check the condition of suspension bushes and coil springs, as a van covering 12,000 miles annually will have worked hard. Verify that the replacement wiper blade from 2024 is still serviceable and that the screen is free from chips in the swept area. A short road test under braking will reveal whether the front discs are causing vibration or uneven braking effort.