2008 Volvo S40 1.6L Petrol · GK58 WKT

The Volvo S40 presents a generally sound mechanical picture. The most recent test, conducted on 23 July 2025 at 38,162 miles, resulted in a clean pass with zero defects recorded. This indicates the vehicle is currently in a stable and fully roadworthy state. The maintenance trend appears to be improving, as the tester found no structural or mechanical failures in the latest inspection, suggesting the previous owner addressed the earlier wear items promptly. The recorded mileage of 38,162 miles over approximately 18 years equates to a low annual average of roughly 2,120 miles. The MOT history shows a steady accumulation pattern, with the mileage increasing by approximately 4,835 miles between July 2024 and July 2025, and a further 3,955 miles between July 2023 and July 2024. This indicates consistent, low-mileage usage rather than long periods of standing, which reduces the risk of deterioration from sitting idle. Despite the clean recent pass, the recurring tyre wear patterns across the 2023 and 2024 tests warrant close physical inspection. The tester flagged rear inner tyres wearing on the edge and below the 1.6mm legal limit in both 2024 and 2023. Uneven inner edge wear typically points to worn suspension bushes or incorrect wheel alignment. The 2024 failure specifically noted excessively worn front suspension arm rear bushes on both sides. A buyer should thoroughly inspect the front suspension bushes, ball joints, and rear axle alignment components to confirm these were properly replaced and aligned. The 2024 test also flagged a non-working nearside headlamp on dipped beam and insufficient windscreen washer fluid. While these are minor electrical and maintenance items, a functioning dipped beam is a legal requirement. Verify both headlamp units operate correctly on main and dipped settings, and check the washer pump and fluid reservoir for blockages or leaks during any test drive.