2004 Maserati Quattroporte 4.2L Petrol · LU04 KYA

A known fault on the Ferrari-derived 4.2-litre V8 and early wet-sump 4.7-litre V8 (F136 family): the cam variators lack adequate check-valve protection, so oil drains off when the car stands and the variators rattle for a couple of seconds on cold start. Maserati never addressed the root cause on early cars; the fix is to add reed valves, and the 4.7 was updated in 2011. Left alone, the rattle can progress to timing concerns and cam-cap damage. A cold-start listening test is the simplest and cheapest check before viewing.

The DuoSelect robotised manual, fitted to 2003–2007 cars, is hard on its clutch, especially in city traffic, slow reversing or when pulling away on hills. Typical clutch life is 20,000–30,000 miles, shortened further by creeping in automatic mode, and a clutch job normally includes the flywheel. The F1 actuation pump and gear-shift actuators are separate known failure points, and a whine when pulling away can indicate input-shaft-bearing wear in the clutch housing. Maserati's SD3 diagnostic tool reads remaining clutch life and kiss-point settings, so a specialist readout is worth asking for.

Both the dry-sump 4.2 and wet-sump 4.7 Ferrari-derived V8s commonly seep oil from the valve-cover gaskets and around the timing case as they age. The leaks are awkward to reach: the valve covers are not quick to remove, and oil cooler lines and gaskets at the rear of the engine can also weep once the manifold area is exposed. Minor seepage is common and manageable, but fresh oil film around the cylinder heads or under the engine should not be ignored, since oil reaching hot components or the exhaust is a fire risk and leaks worsen with mileage.