2004 Volvo S80 2.4L Diesel · ML54 VKB

The vehicle presents a stable roadworthiness profile, evidenced by a consistent history of passes over several years. The most recent test in September 2024 at 145,496 miles resulted in a pass with no defects despite a failure on the same day, which suggests a minor issue was quickly identified and immediately rectified before the retest. Since 2021, the car has maintained a clean record without any recurring mechanical failures or structural advisories. The mileage pattern is consistent with a twenty-two-year-old vehicle, averaging approximately 6,600 miles per year. Between September 2021 and September 2024, the car covered 12,105 miles, representing a steady usage rate of roughly 4,000 miles annually. This low annual mileage typically reduces wear on the drivetrain and engine components, though it can sometimes lead to age-related degradation of rubber and seals. The lack of significant gaps between tests indicates the vehicle has been in regular use rather than sitting for long periods. Given the lack of recorded advisories in the digital history, a physical inspection should focus on the common failure points for a Volvo S80 of this era. A buyer must inspect the front suspension wisharm bushes and coil springs for wear, as these are prone to perish regardless of mileage. The tester should also check for signs of corrosion on the rear subframe and exhaust system, as the MOT does not always capture surface rust until it becomes structural. Checking the brake lines for signs of weeping or perished calipers is also necessary to ensure the low mileage has not resulted in components seizing.