2008 Ford Transit Mk7
Browse our directory of 2008 Ford Transit Mk7 vehicles. Access instant MOT history reports, tax status, and reliability insights for any registration listed below.
Registration Directory
Common Problems & Reliability
The 2008 Ford Transit Mk7 has 6 known issues. 4 of these are classified as serious faults that could be expensive to repair. 2 are moderate concerns worth inspecting before purchase.
Oil Pump Failure (2.2 Duratorq)
SeriousEarly 2.2-litre Euro 4/5 engines have a fragile oil pump design that can fail without warning, causing total engine seizure.
Symptoms: Oil pressure light (too late), Engine knock...
Est. repair cost: £2,000–£4,000
Common-Rail Injector Blow-By and Seal Failure
SeriousThe copper injector sealing washers on 2.2 and 2.4 TDCi Duratorq engines degrade over time, permitting high-pressure combustion blow-by gases to escape up the injector body. This forms hard carbon deposits known as 'black death', risks bore wash, and can cause piston crown melting.
Symptoms: Pungent diesel or exhaust fumes entering the cab through ventilation ducts, Rhythmic chuffing or ticking sound from the cylinder head area at idle...
Est. repair cost: £250–£1,200
Dual-Mass Flywheel and Clutch Premature Wear
SeriousThe dual-mass flywheel on 2.2 and 2.4 TDCi manual models suffers heavy rotational stress from high diesel torque and multi-drop stop-start delivery work. Internal damper springs fatigue and fail, causing heavy clutch judder, starter motor carbon fouling, and eventual clutch slip.
Symptoms: Metallic rattling or knocking sound from the bellhousing area at idle, Rattle noise disappears immediately when the clutch pedal is pressed down...
Est. repair cost: £600–£1,400
Structural Rust on Sills, Steps, and Leaf-Spring Hangers
SeriousMk7 Transits are notoriously susceptible to severe corrosion on UK roads treated with winter salt. Rust takes hold inside the front cab step wells, inner and outer sills, rear wheel arches, and rear leaf-spring chassis mounting brackets, leading to dangerous structural failure and mandatory MOT rejection.
Symptoms: Visible bubbling, blistering, or perforations along outer sills and wheel arches, Spongy or crunching metal when standing on the plastic front cab entry step...
Est. repair cost: £400–£1,800
SCV & PRV Failure
ModerateThe Suction Control Valve and Pressure Relief Valve on the common rail system frequently fail, leading to uneven idling and cutting out.
Symptoms: Engine hunting at idle, Cutting out when coming to a stop...
Est. repair cost: £150–£350
Rear-Wheel-Drive Propshaft Centre Support Bearing Wear
ModerateRear-wheel-drive and four-wheel-drive Mk7 Transits use a multi-piece propshaft supported by intermediate centre bearings encased in rubber dampers. Constant commercial hauling accelerates rubber perishing and bearing race wear, creating low-frequency chassis drone and drivetrain shudder under load.
Symptoms: Dull rumbling, humming, or thumping noise beneath the cargo floor during acceleration, Noticeable cabin vibration through the seats between 30 mph and 50 mph...
Est. repair cost: £180–£450
Buying Tips for the 2008 Ford Transit Mk7
- Check whether a coated-DPF van has needed repeated forced regenerations
- Test the six-speed for whine in top gear under load
- Inspect the rear doors and side loading door alignment for accident repair
Check Any Vehicle
Don't see your specific car listed? Enter any UK registration number for an instant vehicle history check — including MOT history, tax status, finance check, and write-off data.
Free Vehicle Check