2001 Jeep Wrangler 4.0L Petrol · B11 SBU

The TJ's 4.0-litre straight-six is famously reliable but leaky. Autocar reports the 4.0 is prone to water-pump issues and oil leaks from the engine's rear main seal and crankcase vents on top of the valve cover, while RAC advises checking all oil seals. The smaller 2.5-litre has a low oil capacity and can suck air into the sump under heavy braking, risking big-end and con-rod failure, and the water pump is a leak point on both engines. Left unchecked, a low oil level causes terminal engine damage, so oil leaks are the most important mechanical check on a used TJ.

The TJ's recirculating-ball steering and solid-axle suspension develop play over time, and worn ball joints at the end of the Panhard rods or a loose anti-roll bar can trigger the infamous death wobble — a violent front-axle shake that is worse if the Wrangler has been lifted. Autocar warns that vague steering suggests worn ball joints and describes death wobble as alarming behaviour of the front axle, while RAC advises checking the steering for play and all oil seals. Worn universal joints cause drivetrain shunting, and a transfer case can seize if four-wheel drive is not regularly used. This is a safety-critical issue on UK roads.

TJ Wranglers with a soft top regularly suffer canvas tears and a fogged or delaminated rear screen, and both can let water into the cabin. Autocar advises checking that the soft top fits snugly and looking for damp on the seats and floor, while RAC warns to inspect soft-top models for rips, tears or holes in the canvas and the rear screen for evidence of fogging. A split canvas or misted rear screen is not just cosmetic: water ingress ruins carpets and trim, and a fogged rear screen can fail an MOT on rear visibility or condition. Replacement canvas or a new rear screen is a moderate bill, and hard tops can also warp if left in direct sunlight, so the roof and its seals are a key viewing priority on any TJ.