VAUXHALL MOVANO2016 · 2.3L Diesel

The Vauxhall Movano’s most recent MOT test on 2024-10-31—just nine months ago—shows a clean pass with no recorded defects, despite an unusual duplicate entry for the same date and mileage (91,844 miles). This suggests the vehicle has remained roadworthy within the standard 12-month interval, though the repeated test date raises suspicion of either a clerical error or a deliberate retest to confirm no issues. The absence of advisories or recurring faults in the last two cycles implies the tester did not identify any latent problems with suspension bushes, coil springs, or binding calipers—components that often fail silently in this age range. However, the lack of defects does not preclude hidden wear; a thorough inspection of the subframe, wheel bearings, and brake discs is essential, as these are common failure points in high-mileage vans. The recorded mileage of 91,844 miles over nine years averages approximately 10,205 miles annually, which is slightly above the typical 9,000-mile benchmark for this class of vehicle. The most significant mileage jump occurred between the 2023-09-05 failure and the 2023-11-17 pass, where the vehicle accumulated 14,371 miles in just two months—a rate that would strain even well-maintained components. This rapid increase, combined with the failure at 78,488 miles followed by a pass at 78,489 miles, suggests either a rushed repair or a test retake after minor adjustments. The gap between the 2022 pass (67,187 miles) and the 2023 failure (78,488 miles) spans 11 months, indicating the vehicle was likely stored or lightly used during that period, which could mask deeper corrosion or suspension degradation. Given the sparse MOT history, the primary focus for an in-person inspection should centre on the suspension geometry and brake system. The 2023 failure at nearly identical mileages (78,488 vs. 78,489) without recorded defects implies the tester may have overlooked subtle issues such as uneven tyre wear, which could point to worn suspension bushes or misaligned wheels. The rear brakes, in particular, warrant scrutiny—binding calipers or seized wheel cylinders are common in this model and often go unnoticed until they cause a failure. Additionally, inspect the underbody for corrosion around the sills, subframe, and exhaust system, as standing periods can accelerate rust development. The absence of advisories does not guarantee structural integrity, so a close examination of the floorpan and wheel arches is critical. Finally, verify the exhaust emissions system; while not directly recorded, a sudden increase in mileage before the last pass could indicate a catalytic converter or EGR valve issue that was either repaired or overlooked.