2010 Vauxhall Zafira 1.8L Petrol · DS60 LWH

The vehicle shows a history of recurring mechanical degradation particularly regarding the suspension and braking systems. The most recent test in March 2026 at 101,381 miles resulted in a failure due to multiple issues, including a major exhaust flexi leak, a failed lambda reading, and critical nearside front brake pads that had worn below the 1.5mm legal limit. The presence of worn rear axle swivel pins and suspension arm bushes has appeared consistently between 2024 and 2026, suggesting these components are reaching the end of their functional life and require replacement. At 101,381 miles over 16 years, the car averages approximately 6,300 miles per year, which is consistent with typical usage for its age. However, there is a significant gap in the records between December 2020 and April 2022, during which the vehicle covered only about 400 miles. While low mileage, the persistent non-excessive oil leak has been noted on almost every test since 2022, indicating a long-term engine seal characteristic that has not been fully addressed. Immediate attention is required for the exhaust system and the front braking assembly to ensure roadworthiness. The tester also flagged a binding nearside front caliper and an ineffective offside wiper, which point to a lack of preventative maintenance between annual tests. A buyer should specifically inspect the structural integrity of the rear coil springs and the condition of the shock absorbers, as corrosion and oil misting were noted in previous years.